Malibu Boats 1997 Bedienungshandbuch

OWNER’S MANUAL1998 Models

1-2The precautions listed in this manual and on the boat are not all-inclusive. If a procedureor method is not specifically recommended, you must sati

1-3Safety EquipmentU.S. Coast Guard regulations require certain accessory equipment on each boat. For adetailed description, obtain “Federal Requireme

1-44) Navigation Lights: Recreational boats are required to display navigational lightsbetween sunset and sunrise and other periods of reduced visibil

1-5Hazardous ConditionsEvery waterway poses hazards that should be avoided. The following informationoutlines some of the hazards which may be encoun

1-6Carbon MonoxideCarbon Monoxide (CO) is a colorless and odorless gas produced by all engines and fuelburning appliances. Even with the best boat des

1-7Operation By MinorsIf your boat will be operated by a minor, remember to have an adult present at all times.Many states have laws regarding minimum

USWMS SystemIn the USWMS Lateral System, well defined channels are marked with red and blackbuoys. Lateral means the sides of the channel are marked a

1-9FWMS SystemThe FWMS Lateral System is for use on navigable waters except Western Rivers andIntracoastal Waterways.The markings on these buoys are o

1-10Right-Of-WayNotice In general, boats with less maneuverability have right-of-wayover more agile craft. You must stay clear of the vessel withright

1-11OvertakingThe boat that is overtaking one ahead of it is the burdened boat and must make anyadjustments necessary to keep out of the way of the pr

2-1Chapter 2FEATURES & CONTROLSNo other ski boat manufacturer incorporates in their product, as many innovative and technically advanced features,

2-2Fuel GaugeThe fuel gauge indicates the quantity of fuel remaining in thetank when the ignition is in the “ON” position. Although yourfuel tank wil

2-3Voltmeter GaugeThe voltmeter indicates whether the battery is charging ordischarging. The needle should be in the normal range(approximately 14 vo

2-4Accessory Switch PanelsThese panels are located on the dash directly below the standard gauges and are used toactivate the following accessory fea

2-5MEMS Control SystemThe Malibu Electronic Management System (MEMS) is Malibu’s state of the artdashboard design that uses solid state technology to

2-6Computron®ATD SystemYour Malibu may be equipped with the optional Computron®ATD system. This on-boardsoftware-based computer system is the only one

2-7Notice: The four buttons described above have correspondingswitches located on the optional steering wheel. The buttonslocated on the steering whe

2-8Computron®Features & OperationThe Computron ATD system offers several valuable functionsthat provide additional benefits for enjoyment of your

2-9Engine HoursThe engine hours display acts as an odometer for the engine. Engine hours should alwaysbe noted so maintenance and lubricant changes m

iAll information and specifications included in this manual were in effect at the time ofapproval for printing. Malibu Boats West, Inc. reserves the

2-10Demo ModeThis function is provided to allow dealers and owners to demonstrate the functions of theComputron ATD system while the boat is out of th

2-11Steering SystemIt is important that you get the “feel” of your Malibu boat’s steering system. Turn thewheel from full left to full right, and mak

2-12Motorbox CoverThe upholstered motorbox reduces engine noise andprovides protection for the passengers on board. To open,stand on the port side of

2-13SundeckThe passenger seats located in the rear of the boat are designed to comfortably seat threepersons. Some boat models are equipped so that t

2-14Malibu Boats’ “Pivoting-Head”ski pylon is designed fornormal water skiing activities:slalom, jumping,kneeboarding, tricks, andbarefooting. Any ot

2-15Storage AreasBow Storage AreaAccess to a large storage area located in the bow of all models is accessible by lifting upthe bottom lifting strap o

2-16Speedometer PickupsThe speedometer pickups are located on each side of theboat at the bottom of the transom. The pressure applied tothese pickups

2-17Notice: If the canvas top is wet, allow to air dry before storing toprevent mildew.Figure 27 - Bimini TopStereoThe stereo is located under the sta

2-18Warning LabelsWarning labels are displayed at various locations throughout your new Malibu to pointout safety hazards. It is important that you ta

3-1Chapter 3OPERATIONEveryone benefits from the safety of others.TraileringThe trailering information contained in this section describes general guid

ii

3-2Safety ChainsSafety chains on your boat trailerprovide added insurance that it will notbecome completely detached from thetowing vehicle when under

3-3Backing the TrailerBacking the boat trailer may sometimes be a difficult task. It is recommended that youpractice backing the trailer in a vacant

3-4FuelingIt is very important to take special precautions to avoid spillage while fueling your boat.Gasoline vapors are heavier than air and will dev

3-5Shifting/RunningThe throttle lever is located to the right of the driver. When the throttle is vertical, it is inthe “NEUTRAL” position. Located

3-6The steering system must be in good operating condition forsafe boat operation. Frequent inspection, lubrication, andadjustment by your dealer is r

3-7Maneuvering TechniquesSteering response depends on three factors: engine position, motion and throttle.Like an automobile, high speedmaneuvering is

3-8DockingDocking procedures for the new boat owner usually bring surprising results. Remember,operate your boat at slow speeds to avoid accidents an

3-9Before tying-up the boat, be sure to use enough fenders to protect the boat from damage.If possible, tie-up with the bow towards the waves with a g

3-10Towing a SkierWater skiing is a collective effort involving driver, observer and skier. The degree ofunderstanding and cooperation between them di

3-11Communication between the skier and driver is essential. Standard signals have beendeveloped by the American Waterski Association and have been ac

iiiCONTENTSCONTENTS . . . . . . . . . . . . . . . . . . . . . iiiTABLE OF FIGURES. . . . . . . . . . . . . ivINTRODUCTION. . . . . . . . . . . . . . .

3-12Towing Another BoatTowing is normally a last resort because damage can be created by stress from the towinglines or uncontrollability of the boat

3-13PropellersNothing is more important to the proper performance of your boat than the condition ofthe propeller. Even slight propeller damage can me

4-1Chapter 4CARE AND MAINTENANCEFollowing the guidelines discussed in this sectionwill protect the investment you have made by preserving he beauty an

4-22) Wax the boat hull and deck after every three or four outings to decrease waterfriction and to lessen the potential for staining or spotting the

Engine/Drive Train EngineFor information on engine service, maintenance, and break-in period, please refer to yourengine owner’s manual. The maintenan

4-4ElectricalBatteryYour Malibu boat is equipped with a standard 12-volt battery. The battery comes with anon-metallic box to help contain spills and

4-5MiscellaneousHardwareMost of the metal hardware on your boat consists of brass, stainless steel, or aluminumand should be cleaned on a periodic bas

4-6Warranty InformationMalibu Boats Transferable Lifetime Limited WarrantyMalibu Boats West, Inc. warrants to the Original Retail Purchaser that the h

4-7Notification of a claim or defect can be made though the selling dealer or by writingdirectly to Malibu Boats. Information needed for processing a

ivTable of FiguresFigure 1 - Personal Flotation Devices . . . . . . . . . . . . . . . . 1-3Figure 2 - Tachometer . . . . . . . . . . . . . . . . . .

4-8Service Away From HomeIf you are away from home and require service to your boat, contact your nearestauthorized Malibu dealer. Check the yellow p

4-9GlossaryAFT: To the rear of the boat near the stern. Generally used to givedirections.BEAM: The widest portion of the hull.BILGE: The lowest porti

4-10IndexAAccessory Switch Panels. . . . . . . . . . . 2-4Anchoring . . . . . . . . . . . . . . . . . . . . . 3-12BBasic Rules of the Road. . . . . .

SERVICE/MAINTENANCE LOGHOURDATE READING SERVICE/REPAIRS PERFORMED

Corporate HeadquartersMalibu Boats1861 Grogan AvenueMerced, CA 95340Phone: (209) 383-7469Fax: (209) 383-0499Tennessee PlantMalibu Boats5075 Kimberly W

vINTRODUCTIONOver the years, you have watched us grow into one of the most respected boat builders inthe world. And undoubtedly, somewhere you have r

1-1Chapter 1BOATING SAFETYAt Malibu, safety is not an option!General PrecautionsYour Malibu boat has been constructed to meet all U.S. Coast Guard and